conceptcarz.com

1966 Chevrolet Electrovair II Experimental

1966 Chevrolet Electrovair II Experimental 1966 Chevrolet Electrovair II Experimental 1966 Chevrolet Electrovair II Experimental The Electrovair II Experimental vehicle was built in 1966 and was GM's second post-war attempt at developing a viable electric vehicle. The Electrovair II addressed the problem of lead-acid battery weight and package size demonstrated with its predecessor by utilizing a new battery technology, silver zinc. This battery development delivered power in a package three times lighter and considerably smaller than lead-acid batteries. The Electrovair II showed promise, but it experienced the same limitations that have restricted electric car acceptance; limited range and frequent recharging requirements.
1966 Chevrolet Electrovair II Experimental 1966 Chevrolet Electrovair II Experimental 1966 Chevrolet Electrovair II Experimental Even as far back as the mid-1960s, General Motors was earnestly exploring futuristic vehicles with alternative power sources, including electric; and this 1966 Electrovair II concept was a test bed for electric motor and control development. It was actually GM's second attempt at an electric-powered Corvair. But when the first one didn't meet the engineers 'hoped-for performance' they started from scratch with a new one using a 532-volt silver-zinc battery pack stuffed into its front truck and what had been its rear engine compartment.

Because it used comparatively light and compact silver-zinc batteries, the Electrovair II weighs about 800 pounds more than a standard Corvair, where an equivalent pack of conventional lead acid batteries would have weighed closer to 2,600 pounds. The silver-zinc batteries also offered good energy storage and high peak power, but their downsides were high cost and the unfortunate reality that they were essential worn out after only about 100 recharges. The car's 115 horsepower AC-Induction motor that provided acceleration competitive with the gasoline version and an 80-mph top speed. Its major disadvantage was a driving range of only 40-80 miles before recharging.

Strictly an engineering exercise, the Electrovair II was never intended for production. With relatively stable and cheap gasoline prices in the mid-1960s, the American public wasn't exactly clamoring for electric cars at the time.

Time magazine named it one of 'The 50 Worst Cars of All Time.' Ralph Nader highlighted its design flaws in his influential book Unsafe at Any Speed. Yet the Chevrolet Corvair, which faced more negative press during its lifespan than any other car of the era, continues to have a loyal following of true enthusiasts.

Different from any American cars before or since, the unique Corvair has become most notable for its flaws. The car had its merits as well, but the more agreeable facets of the Corvair have been largely disregarded by the public and held onto only by an adoring group of fans enamored with the vehicle.

A rear-engined car, the primary flaw of the Corvair sprang from Chevrolet's inexperience with the new drivetrain layout. The Corvair was designed to be a mass-produced compact car able to compete with the incoming wave of tidy foreign vehicles. For inspiration, Chevrolet looked to the king of the compact—Volkswagen.

With a name that translates literally to 'People's Car,' Volkswagen had nailed the formula for affordable and charming transportation with the evergreen Beetle. When the Corvair was introduced, it borrowed heavily from the Beetle. Like the VW, the Corvair used an air-cooled engine mounted at the rear, with a trunk located up front. The Corvair also used a swing-axle rear suspension similar to the Volkswagen's. While VW had many years to perfect its engine and suspension, Chevrolet jumped right in with the Corvair. With no real experience making such cars, Chevy's new compact was bound to have some serious teething issues.

When it debuted for the 1960 model year, the Corvair suffered from grave problems. Its rigid steering column was aimed just right to impale unlucky drivers when the cars were involved with collisions. The car's most notable fault, though, came from its suspension design. Though the light and underpowered Volkswagens could use a similar design without serious problems, the heavier and more powerful Corvairs developed dangerous handling characteristics due to the use of a swing-arm rear suspension.

Under hard cornering, the inside rear wheel of Corvairs had a tendency to tuck. When this happened, and it happened often, the cars became uncontrollable. With barely any surface area gripping the road at the back of the car, a tucked wheel could easily cause a spinout. Even worse, many cars would roll over when the suspension gave out in a turn.

Chevrolet recognized the problem and began working to remedy it as early as 1962. For 1964, a transverse spring was installed to compensate for camber changes under cornering. By 1965, with the introduction of the second generation Corvair, an entirely new suspension design had replaced the flawed swing-axle layout. Salvation came late, though. Also released for 1965 was Ralph Nader's book Unsafe at Any Speed that targeted the glaring problems of the early Corvairs. The improved models were hurt by the infamous reputation of their predecessors. Sales slowed to a trickle, and production was ended after the 1969 model year.

Despite the follies of the early cars, there was plenty to like about the Corvair. Its styling was crisp and clean with a sporting flair that couldn't be seen on other American compacts. The forward slanting nose with its four small headlights and absence of a grille looked distinctive and fresh. The car's lines were taut and athletic, a welcome step away from the American excess of just a few years prior.

Later Corvairs, with their improved rear suspensions, offered engaging driving dynamics. The improved handling made Corvairs fun cars in the corners. The air-cooled, aluminum flat sixes were versatile engines. Offered in 145ci and 164ci displacements, they produced anywhere from 80 to 180 horsepower. More affordable trim levels, like the 500 and 700, made due with less power while the sportier Corsa, Monza, and Spyder trims were all given more gusto. Four carburetors were offered on some models, and for the 1965 and 1966 model years there was even a turbocharged variant of the 164ci engine. It was this turbo engine that, when ordered in the Corsa, put out a hearty 180hp at 4,000rpm. The relatively light weight of the Corvair coupled with such power provided astounding acceleration. The ¼ mile could be achieved in the 13-second range.

Ushering in such innovations in an American car was a brave move for Chevrolet. The Corvair had dire flaws—problems that ultimately led to the car's end. It represented Chevy's willingness to take risks, though, and in doing so showed that the American car industry could step outside its bounds and create its own distinctive brand of transportation to take on a new class of cars from all over the world. With the support of a large group of admirers who continue to voice their praise over the cynics' criticism, the Corvair has become the car world's most successful failure.

Sources:

Aube, Gary. Corvair Corsa Web.23 Jul 2009. http://www.corvaircorsa.com/.

GM: The First 75 Years of Transportation Products. Second. Detroit: Automobile Quarterly Publications, 1983. Print.

By Evan Acuña
The Corvair came on the scene in 1959 and featured a flat-six engine mounted in mid-ship. Even with putting the engine in the middle of the vehicle, the weight distribution was not evenly distributed. The engine sat behind the rear axle and this actually caused handling problems. The vehicle's main competition was the VW Bug and the Porsche 911. It was originally built to compete with the Bug, but with the flat-six engine, it was more in the Porsche 911 league. But with the poor handling, it was in an undesirable class of its own. The handling issues were addressed in 1965 when new suspensions with upper and lower control arms were added. But when comedian Eddie Kovacs was killed due to over-steer, public confidence, and sales plummeted. Chevrolet tried to save the Corvairs by introducing media campaigns that focused on the new suspension. Race drivers were used to demonstrate the car's ability. However, it was not enough, and Chevrolet finally ended production of the Corvair in 1969.

The front of the vehicle did not have a grill. This was because the engine was air-cooled, so a grill was not needed.

The car came with fifteen different color options on the outside and eight on the inside. The retractable room was foldable, and an automatic option available for an additional charge. In 1962, a turbocharged version was added to the line-up in an attempt to boost sales and improve the image of the vehicle as a sports car. A top speed of 115 mph could be ascertained with the turbocharger with a zero-to-sixty time of about 10.8. In 1966, the vehicle received styling updates and was named the Corvair Corsa. Drum brakes were always used. The vehicle came in a variety of gearboxes such as a three-speed manual, four-speed manual, or an optional two-speed automatic. The body was integral chassis with a two-door steel body.

The name Corvair came about by breeding the Corvette and Bel Air together, two trademark names of Chevrolet.


By Daniel Vaughan | Jul 2009

1966 Chevrolet Electrovair II Experimental Vehicle Profiles

Recent Vehicle Additions

Related Automotive News

DS Automobiles Opens Reservations For DS 3 Crossback E-Tense The Haute Couture All-Electric Premium Compact SUV

DS Automobiles Opens Reservations For DS 3 Crossback E-Tense The Haute Couture All-Electric Premium Compact SUV

DS Automobiles opens reservations for its 100 electric DS 3 CROSSBACK E-TENSE – the first ever electric DS car - ahead of first deliveries in January DS 3 CROSSBACK E-TENSE is a latest generation model with prices from £32,350*br...
BRITAIN'S RACING LORD AIMS TO RAISE SUB-1000 KG ELECTRIC CAR WORLD LAND SPEED RECORD AT BONNEVILLE SPEED SHOOTOUT

BRITAIN'S RACING LORD AIMS TO RAISE SUB-1000 KG ELECTRIC CAR WORLD LAND SPEED RECORD AT BONNEVILLE SPEED SHOOTOUT

10 September 2013 Technology entrepreneur, former UK science minister and racing driver Lord (Paul) Drayson is bringing his spectacular Drayson B12 69EV electric Le Mans Prototype racing car to the Bonneville Salt Flats in Utah in an attempt...
NISSAN TO SHOWCASE THE ZEOD RC AT FUJI FIA WORLD ENDURANCE CHAMPIONSHIP EVENT

NISSAN TO SHOWCASE THE ZEOD RC AT FUJI FIA WORLD ENDURANCE CHAMPIONSHIP EVENT

IRVINE, Calif. - Japanese fans will have the first opportunity to see the revolutionary Nissan ZEOD RC in action when the car makes its public on-track debut at this years Fuji Speedway round of the FIA World Endurance Championship. Running...
Cadillac ELR Tech Targets Engaging Driving Dynamics

Cadillac ELR Tech Targets Engaging Driving Dynamics

Advanced suspension, steering systems provide smooth ride, precise handling DETROIT – Drivers expect hybrid and electric cars to have advanced battery and drive systems that make smart use of energy. Cadillacs upcoming electrified luxu...
World'S Fastest Ev – Detroit Electric Sp:01 – Makes Global Public Debut At Shanghai Motor Show

World'S Fastest Ev – Detroit Electric Sp:01 – Makes Global Public Debut At Shanghai Motor Show

Limited-edition SP01 is worlds fastest pure-electric production sports car– 155 mph (249 kmh)top speed and 0-62 mph (0-100kmh) in 3.7 seconds SP01boasts a carbon-fibre body, luxurious and high-tech interior, and range of over 180 milesb...