| Component | HYBRID PROPULSION SYSTEM |
|---|---|
| Manufacturer | Chrysler (FCA US, LLC) |
| NHTSA Campaign ID | 22V077000 |
| Summary | Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV). A vehicle fire can occur when parked, even with the ignition in the 'Off' position. |
| Consequence | A vehicle fire increases the risk of injury. |
| Remedy | Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim letters, informing owners of the safety risk were mailed on February 25, 2022. Final owner notification letters were mailed October 6, 2022. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Z11. |
| Notes | Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov. |
| Component | ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES |
|---|---|
| Manufacturer | Chrysler (FCA US LLC) |
| NHTSA Campaign ID | 20V334000 |
| Summary | Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ('PHEV'). The 12 volt isolator post located behind the driver's seat may develop high resistance. |
| Consequence | A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off. |
| Remedy | FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak. |
| Notes | Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| Component | ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD |
|---|---|
| Manufacturer | Chrysler (FCA US LLC) |
| NHTSA Campaign ID | 18V524000 |
| Summary | Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition. |
| Consequence | A vehicle stall can increase the risk of a crash. |
| Remedy | Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87. |
| Notes | Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
| Component | HYBRID PROPULSION SYSTEM |
|---|---|
| Manufacturer | Chrysler (FCA US LLC) |
| Mfr Report Date | 20160816 |
| NHTSA Campaign ID | 18V740000 |
| Summary | Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst. |
| Consequence | The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire. |
| Remedy | FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94. |
| Notes | Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-434-9153), or go to www.safercar.gov. |
| Component | SUSPENSION:FRONT:CONTROL ARM:LOWER ARM |
|---|---|
| Manufacturer | Chrysler (FCA US LLC) |
| Mfr Report Date | 20171101 |
| NHTSA Campaign ID | 19V143000 |
| Summary | Chrysler (FCA US LLC) is recalling certain 2018 Chrysler Pacifica and Pacifica hybrid vehicles. The right front lower control arm may separate from the steering knuckle. |
| Consequence | A control arm separation could increase the risk of a crash. |
| Remedy | Chrysler will notify owners, and dealers will inspect the right front knuckle and lower control arm for damage, replacing the components as necessary. The right front lower control arm knuckle pinch bolt will be replaced with a larger-diameter pinch bolt. These repairs will be performed free of charge. The recall began April 26, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V15. |
| Notes | Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov. |
Data updated January 2023
2018 Chrysler Pacifica Hybrid Recall FAQs (show)
Q: Does the 2018 Chrysler Pacifica Hybrid have any vehicle recalls?
A: Yes, the 2018 Chrysler Pacifica Hybrid has atleast 7 recalls.Q: What are the 2018 Chrysler Pacifica Hybrid recalls?
A: The 2018 Chrysler Pacifica Hybrid recalls include: HYBRID PROPULSION SYSTEM, ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES, ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD, HYBRID PROPULSION SYSTEM, SUSPENSION:FRONT:CONTROL ARM:LOWER ARM.
A: Yes, the 2018 Chrysler Pacifica Hybrid has atleast 7 recalls.Q: What are the 2018 Chrysler Pacifica Hybrid recalls?
A: The 2018 Chrysler Pacifica Hybrid recalls include: HYBRID PROPULSION SYSTEM, ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES, ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD, HYBRID PROPULSION SYSTEM, SUSPENSION:FRONT:CONTROL ARM:LOWER ARM.