Since 1995, the Toyota Tacoma is a compact pickup truck both manufactured and produced by the Toyota Motor Corporation. For 2005 the second generation Tacoma was named Motor Trend Magazine's Truck of the Year. The Tacoma received its name after the City of Tacoma, Washington, USA. The Tacoma name originated from the worldwide Hilux, and prior to this the Hilux was marketed in the US, under the name Toyota Pickup. Three engines were available for the Toyota Tacoma; the 2.4 L four cylinder which was rated at 142 hp and 160 lb/ft of torque, the 2.7 L four cylinder which was rated at 150 hp and 177lb/ft of torque and finally the 3.4 L V6 rated at 190 hp and 22 lb/ft of torque. The 2.4L offered the highest MPG at 29, the 2.7L gave 26 miles per US gallon, and the 3.4L gave only 22 miles per US gallon.
5-stud wheel lug patterns were found on Two-wheel drive Tacoma's, while the 2.4 L and 3.4 L engines were available depending on options. Both automatic and manual transmissions were available. Four-wheel drive Tacoma's came with six-stud wheel lug patterns, which had been used early on pre-Tacoma trucks. The frame of the Tacoma is fully boxed until promptly transitioning into a c-frame section after the front leaf spring mount bracket. The automatic transmission was an A340F while the 3.4 V's manual transmission was an R150F. Single cab Tacoma's came with the option of a manual transmission with the 3.4 V6 engine from 1995 until 1997. Following 1998 the single cabs only received a 2.7 or a 2.4 4-cyl from factory. Also in this year TRD packages began.
Pre-runner models also began in this year and they shared the same front and rear suspensions parts and geometry, styling, frame and engine options as 4X4 Tacoma's of this year range. These models also had the options of the TRD Off-Road package which received a rear differential locker if it was a V6 model. The main downside was there wasn't an option of a 5-speed transmission.
The Toyota Tacoma sold quite well in the first few years of production, appealing to many young buyers. During the first generation the Tacoma underwent two cosmetic facelifts, the first in 1998 and the second in 2001. The revisions involved new headlights and new grilles. Mechanically the changes included a switch to distributor-less ignitions in 1997 and in 1998 longer rear leaf springs. Also in 1998 a passenger-side airbag was added to the Tacoma, while the driver's side air bag was 'depowered'. Following the 2000 model year all 4X4 models came with Toyota's Automatic Differential Disconnect system.
In 2001 the main revision for the Tacoma was a new crew cab (four door) model being added to the lineup. The crew cab came with four doors, while the Tacoma extended cab continued to open with two doors. A 6 foot bed came with the extended cab while the crew cab came with a 5 foot 5-inch bed. Unfortunately many customers were not happy with small crew cab beds, but there wasn't much of a market for larger truck beds with competitors. Toyota rolled out their new S-Runner trim package in 2001 which came with a 3.4 liter V6 engine, 16-inch alloy wheels and a 5 speed manual transmission with Tokico gas shocks. Only 200 units were produced from 2001 until 2004. The Toyota Tacoma went up 16.5 percent in sales from its earlier years and it continued to only rise in popularity. The Tacoma was ahead of the Nissan Frontier and the Dodge Dakota in 2004, only 2.2 percent behind in sales to the Ford Ranger.
The second generation of the Tacoma was unveiled at the 2004 Chicago Auto show. This generation was assembled in Tijuana, Mexico and Fremont, California, while the plastic/composite beds were all constructed in Mexico. This continued until August of 2009 when Toyota announced that it would relocate Tacoma production from Fremont to San Antonio, Texas, therefore consolidating with it's Toyota Tundra production line and having all American made Toyota pickups manufactured at one facility.
This new Tacoma was a bigger, meatier, more powerful Tacoma for 2005 available in eighteen various configurations that included three cab configurations, four transmissions, two engines, and two different bed lengths. The 4.0-liter 1GR-FE V6 replaced the original 3.4-liter V. The new Tacoma V6 had many enhancements that included a new 6500 pound tow rating and a payload capacity of 1650 pounds. It produced 236 horsepower and 266 foot-pounds of torque. The brand new smaller 2.7-liter 2TR-FE 4-cylinder alternative in cheaper models was rated at 159 hp and 180 lb/ft of torque.
An X-Runner trim was also introduced this year which replaced the slow selling S-Runner trim from the earlier generation. This model features the 1GR-FE was mated to a six speed manual transmission, 18 in alloy wheels which were lowered two inches from the factory and included an X-Brace suspension package. Also included on the X-Runner trim was a Down-Hill Assist Control (DAC) and Hill-Start Assist Control (HAC) on models that were outfitted with the optional Toyota Racing Development (TRD) Off-Road package. HAC prevents the car from rolling backwards on hills while DAC automatically applies braking during downhill descents. Optional features included limited-slip differential or a rear locking differential. All Tacoma's were manufactured with a composite inner bed that included a deck rail system with four tie-down cleats, storage boxes, hook-pins, and a power outlet. The tie-down cleats were rated to hold up to 220lbs.
The 2006 Tacoma rolled out with a bit more flair than the previous year. This year featured some options standard. For 2007 the Tacoma added 2 all-new interior colors. Not much changed aesthetically for the 2008 model year. For 2008 Toyota announced a 15 year, unlimited mileage corrosion warrant for 1995-2000 models because of insufficient rust-proofing and frame corrosion issues that affected a small amount of Tacoma's. Toyota offered to either repair the frame or buy back the truck for 1.5 times its KBB retail value.
Safety features were implemented for 2009 and the Tacoma no longer offered a mechanical limited slip different instead of an open differential which uses individual wheel braking to simulate a mechanical LSD or 'Auto-LSD'. Off-road TRD models continue to arrive equipped with a locking rear differential. For this year a slightly improved grill was added on some models, along with LED taillamps. The X-Runner, TRD Sport and TRD Offroad models included smoked headlamp trim. Now standard were auxiliary audio input. Four new exterior colors were added to the Tacoma and the Access/Double Cab trucks received two new ceiling mounted speakers and available backup monitor.
Following GM's bankruptcy, GM abandoned the NUMMI venture. Toyota killed all Corolla and Tacoma production. For 2010 all Tacoma production was relocated to Toyota's Texas plant in San Antonio. The Tacoma was build alongside the Tundra, and by doing this, Toyota now has all of its NA truck production in one plant. In 2012 the Tacoma is expected to be redesigned and re-engineered, two years following the release of the new 4Runner.
The Tacoma arrived standard with brake assist, anti-lock brakes, and electronic brakeforce distribution. A rollover sensor was added in 2008 which deployed the side curtain airbags in the event of a rollover in Tacoma's equipped with the optional side airbags. Starting in 2009, all Tacoma's featured Toyota's Star Safety System which added traction control and Vehicle Stability Control. Also standard were front row side torso airbags and side curtain airbags for both rows, along with active head restraints. With active head restraints, in 2009 the Tacoma was given the IIHS's Top Safety Pick award. The Tacoma Access Cab received standard power windows and door locks along with redesigned rear seats for passenger comfort and convenience. Higher trim levels offered optional Bluetooth enabled Premium JBL 6-CD audio systems with integrated XL satellite radio.
A limited production trim, the Toyota X-Runner was only available in three colors each year and only four colors today. The X-Runner was available in Speedway Blue, Black San Pearl and Radiant Red from 2005 until 2008.The Radiant Red was discontinued in 2009 and replaced with Barcelona Red Metallic. The main difference between the X-Runner and other packages were the updates to the suspension, a 3.15 Final Drive ratio and ground effects. To stiffen up the back end, the Toyota added a rear mounted X-Brace. The chassis was also stiffened more by adding two additional support braces to the frame. One could purchase an optional big brake kit by TRD available on the X-Runner which consisted of a 332 mm slotted rotor and 4 piston caliper. This big brake kit was designed by StopTech.
The 2010 Tacoma appealed to drivers who needed a mid-size car or compact pickup loaded with latest media amenities and top of the line safety features in addition to fuel efficiency and hauling capabilities. The outside remained basically unchanged from the previous year. The '10 trucks came in three cab styles; the Tacoma Regular Cab, Double Cab with four side doors and extended Access Cab with hinged rear doors. The 2010 Tacoma was equipped with the most advanced DynamicControl technology and Electronic Throttle Control System with intelligence. The Tacoma is a popular seller in the mid-size pickup truck category.
by Jessican Donaldson