2005 Saturn Relay Specifications

Specifications

2005 2006 2007

Features

Engine Location :	Front
Drive Type :	Front Wheel (standard), AWD
Body / Chassis :	Unibody
Production Years for Series :	2005 - 2007
MPG City :	18
MPG Highway :	24
Combined MPG :	21.00

Engine & Transmission

V 6 60-degree \| 3500 3.5L
Displacement :	3500 cc \| 213.6 cu in. \| 3.5 L.
Power :	200 BHP (147.2 KW) @ 5200 RPM
Torque :	220 Ft-Lbs (298 NM) @ 4400 RPM
Bore :	3.7 in \| 94 mm.
Stroke :	3.3 in \| 84 mm.
Compression :	9.80:1
Valvetrain :	12 OHV (2.0 valves per cylinder)
Cylinder Block :	Cast-iron
Cylinder Head :	Cast-Aluminum
Redline :	6000 RPM
Ignition system :	Quick Sync 24X; also coil near plug, composite distributor, platinum-tipped spark plugs

Transmission:
4 Automatic Hydra-Matic 4T65-E

Gear Ratios

1st Gear :	2.92
2nd Gear :	1.56
3rd Gear :	1.00
4th Gear :	0.70

Handling

Recall

Component	STEERING
Manufacturer	DORMAN PRODUCTS, INC.
NHTSA Campaign ID	09E005000
Summary	DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S 'OE SOLUTIONS
Consequence	A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Remedy	DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.
Notes	THIS RECALL ONLY PERTAINS TO AFTERMARKET DORMAN STEERING KNUCKLES AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON VEHICLES MANUFACTURED BY GENERAL MOTORS CORPORATION.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO

Component	SEATS:MID/REAR ASSEMBLY
Manufacturer	GENERAL MOTORS CORP.
Mfr Report Date	20040601
NHTSA Campaign ID	05V061000
Summary	ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence	IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy	DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Notes	GM RECALL NO. 05015.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV.

Component	PARKING BRAKE
Manufacturer	GENERAL MOTORS CORP.
Mfr Report Date	20050201
NHTSA Campaign ID	05V287000
Summary	CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence	WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy	DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
Notes	GM RECALL NO. 05059. CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO SAFERCAR.GOV.

Information provided by NHTSA
Data updated June 2024

2005 Averages

Avg. Household Income :	$46,326
Avg. Home :	$297,000
Avg. Gallon of Gas :	$2.24
Total Car Production :	11,946,653

2005 Saturn Relay FAQs (show)

Popular frequently asked questions include:

What are the dimension and mechanical specifications of the 2005 Saturn Relay?
How many 2005 Saturn Relay were produced?
How powerful was the 2005 Saturn Relay? Was the 2005 Saturn Relay popular? Was the 2005 Saturn Relay expensive? What was the fuel economy of the 2005 Saturn Relay?

Q: What is the wheelbase size of the 2005 Saturn Relay? A: The 2005 Saturn Relay has a wheelbase size of 121.10 inches.

Q: What is the length of the 2005 Saturn Relay? A: The 2005 Saturn Relay has a length of 205.00 inches.

Q: What is the width of the 2005 Saturn Relay? A: The 2005 Saturn Relay has a width of 72.00 inches.

Q: How much headroom does the 2005 Saturn Relay have?A: The 2005 Saturn Relay has 39.80 inches of headroom.

Q: How much legroom does the 2005 Saturn Relay have?A: The 2005 Saturn Relay has legroom of 39.90 inches.

Q: What is the 2005 Saturn Relay's towing capacity?A: The 2005 Saturn Relay has a towing capaicty of 3500.00 lbs.

Q: What is the bodystyle of the 2005 Saturn Relay? A: The 2005 Saturn Relay was a Minivan.

Q: What engine did the 2005 Saturn Relay have? A: The engine powering the 2005 Saturn Relay was a V 6 (3500 cc | 213.6 cu in. | 3.5 L.) with 200 BHP (147.2 KW) @ 5200 RPM and 220 Ft-Lbs (298 NM) @ 4400 RPM.

Q: What transmission did the 2005 Saturn Relay have? A: The 2005 Saturn Relay had a 4 speed Automatic Hydra-Matic 4T65-E gearbox.